View and Download Polaris Sportsman X2 owner’s manual for maintenance and safety online. Sportsman X2 Offroad Vehicle pdf manual. Atv polaris sportsman / efi / x2 efi ( pages). Offroad Vehicle Polaris Magnum Owner’s Manual Supplement. Atv (5 pages). View and Download Polaris Scrambler 4X4 owner’s manual online. Polaris Car User Manual. Scrambler 4X4 Offroad Vehicle pdf manual.

Author: Mooguran Samukree
Country: Sudan
Language: English (Spanish)
Genre: Politics
Published (Last): 20 December 2015
Pages: 394
PDF File Size: 11.8 Mb
ePub File Size: 12.77 Mb
ISBN: 922-6-36073-560-7
Downloads: 68533
Price: Free* [*Free Regsitration Required]
Uploader: Kigagul

Drain the housing before storing the vehicle. Drain and properly dispose of transmission oil. Oil may need to be changed more frequently if Polaris Premium 4 is not used.

Learn more about Amazon Prime. To enter the diagnostics mode: Grasp the rear of the side panel near the rear cab. Open the access door.

Cover the vehicle with a genuine Polaris cover. Your key can be duplicated only by mating a Polaris key blank with one of your existing sportxman, so if both keys are lost, the ignition switch must be replaced.

See your Polaris dealer about configuring the vehicle to be certified to tow a trailer on-road. Position polzris vehicle on a Full level surface. Install the transmission switch and secure the switch with the retaining ring.

The handlebars may also be locked in the full left position. The U-shaped roll pin in front prop shaft. When the switch is on 2X4, the ATV is in two-wheel drive at all times. Apply the brakes lightly for stopping. ComiXology Thousands of Digital Comics. Take a training course. Remove the T27 screws that secure the output gear 21 with a T27 hex socket 5500 driver. Eye Protection Do not depend on eyeglasses or sunglasses for eye protection. Install the cam assembly helix over the shaft. Always check to be sure the parking brake is disengaged before operating.


Polaris 2007 Scrambler 500 4X4 Owner’s Manual

Never run an engine in an enclosed area. Polaris oplaris gives a one year limited warranty on the final drive chain for failure due to defects. Polaris also gives a one year limited warranty on the final drive chain for failure due to defects. Use new should be seated below the U-shaped insert. Release the brake lever.

Loosen the clamp and remove the filter.

Before shifting into reverse gear, always check for obstacles or people behind the ATV. Slow down when entering slippery areas. Avoid backing on inclines, and avoid turning at sharp angles. Do not operate on excessively rough, slippery or loose terrain. Avoid crossing the side of a hill when possible. Replace component as wear.

See page 40 for Blink Codes and Failure Descriptions. Periodic Maintenance Chart beginning on page Record your vehicle’s identification numbers and key number in the spaces provided. Owner’s Manual Polaris industries all-terrain vehicle owner’s manual pages. To clear codes manually, disconnect the positive battery lead for 20 seconds.


Use caution when applying the auxiliary brake. Pvt Troubleshooting During this procedure, the throttle should not be held at the full position for more than 10 seconds.

Do not scratch the ring lands. A sealed battery can be identi- fied by its flat covers on the top of the battery.


Spark plug condition is indicative of engine operation. Failure to follow the warnings contained in this mamual can result in serious injury or death. Make sure they are not cracked or separated from housing.

Allow it to idle for 30 seconds. Please see your Polaris dealer for all major repairs. Lubricate Inspect all cables and lubricate with Polaris Cable Lubricant. Remove the upper headlight pod.

Inspect the backlash pad B for excessive wear. If you move or are traveling within kwners country where your vehicle was purchased, Warranty or Service Bulletin repairs may be requested from any authorized Polaris dealer who sells the same line as your vehicle.

Hot components can cause serious burns and fire.

Author: admin